Strength Properties of Concrete with Partial Replacement ...

Find the optimum percentage of quarry dust that can be replaced for cement. Study the effect of strength properties with the optimum % cement replacement with another fine aggregate namely bottom ash. Scope of project work was to Make use of the locally available granite quarry dust as partial replacement of cement.

Use of Quarry Dust as fine aggregates by Partial ...

1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

CiteSeerX — Partial Replacement of Sand with Quarry Dust ...

This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand in concrete.

EXPERIMENTAL INVESTIGATION ON PARTIAL …

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT OF CEMENT BY SUGARCANE ASH AND QUARRY DUST AS FINE AGGREGATE. Dr.R.Saravanan 1, ... 20% and 30%.And the Sand can be r eplaced by quarry dust in the range of 20%, 30% and 40%.Here the behavior of the Sugarcane ash and quarry dust should be

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL …

to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete. 1.2 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete. The introduction of quarry dust for mixing is limited due to its high fineness.

GGBS and Fine Aggregate with Quarry Dust Concrete by ...

as a replacement of Natural Sand due to its scarcity. The replacement percentages of Cement with GGBS are 20%, 40% and 60% by weight and 25%, 50%, 75% and of Quarry Dust are used as a replacement of Natural Sand. Various combinations of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.

What are the advantages of using quarry dust as fine ...

May 23, 2017· The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduc...

Partial Replacement of Sand by Quarry Dust in Concrete

investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Partial Replacement of Sand with Quarry Dust in Concrete ...

This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand in concrete.

Quarry Dust Uses in a Construction Project

Jun 06, 2016· Quarry dust uses is not limited to highway projects, in construction projects that involves homes building, it is fast becoming popular too. Partial replacement of sand with quarry dust will make good concrete that is well desired in residential construction. The final product is strong bricks, slabs or tiles that are produced at lower cost ...

Experimental Investigation on the Effect of Replacement …

obtained with the partial replacement of river sand with 20% CGF, as against values of 35.00N/mm2 and 1.75N/mm2 obtained with the use of river sand as fine aggregate. Based Experimental Investigation on the Effect of Replacement of Sand by Quarry Dust in Hollow Concrete Block for Different Mix Proportions

EFFECT OF QUARRY DUST AS PARTIAL REPLACEMENT OF SAND IN ...

The effect of quarry dust on the flexural strength of concrete has been experimentally studied and reported in this paper. Concrete used was prepared by replacing 25% and of sand by weight ...

Effects of The Total and Partial Replacement of Sharp Sand ...

Previous research carried out on this shows positive results and hence quarry dust has very recently gained good attention to be used as an effective filler material instead of sharp sand. This project will investigate the effect of the total and partial replacement of sharp sand with quarry dust on concrete.

International Journal of Innovative Technology and ...

as partial replacement for cement to have higher workability, long term strength and to make the concrete more economically available. This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some

Quarry Dust as a Partial Replacement of Coarse Aggregates ...

Karthicket al (2014), in his study on the usage of quarry dust as a partial replacement for sand in concrete found that the compressive strength of concrete cubes at 28 days of curing was improved as high as 35.26% above the strength of conventional concrete when 40% of the fine aggregate was replaced with quarry dust by weight.

Study of Concrete Involving Use of Quarry dust as Partial ...

of quarry dust and the suitability of those properties to enable quarry dust (Celik et.al.,) to be used as partial replacement material for sand in concrete. The use of quarry dust in concrete is desirable because of its benefits such as useful disposal of by products, reduction of river sand consumption as well as increasing the strength

Experiment on Foam Concrete with Quarry Dust as Partial ...

compressive strength of foam concrete by using quarry as partial sand replacement material. This report presents the feasibility of the usage of quarry dust as 10 %, 20 % and 30 % and 40% substitutes for sand in foam concrete. ... Replacement of sand with quarry dust is done only for

partial replacement of sand with quarry dust

Partial replacement of sand with quarry dust will make good concrete that is well desired in residential construction The final product is strong bricks, slabs or tiles that are produced at lower cost compare to using sand. Experimental Study on Partial Replacement of Fine, ...

partial replacement of sand by quarry dust

on partial replacement of sand with quarry dust in concrete This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial ...

Research Paper EXPERIMENTAL STUDY ON PARTIAL …

Research Paper EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT WITH QUARRY DUST Venkata Sairam Kumar N. 1, ... maximum content of quarry dust partial replacement of cement in concrete. The percentages of quarry dust partial ... Krishna river sand confirmed to grading zone-III as per IS: 383-1970, having specific ...

Study on Compressive Strength of Quarry Dust as Fine ...

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Experimental Study on Concrete and Cement Plaster Using ...

on partial replacement of sand with quarry dust in concrete. This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust …

PARTIAL REPLACEMENT OF SAND BY QUARRY DUST IN …

partial replacement of sand by Quarry dust by 20%, 30%, 40% and 50%. The compressive strength of concrete cubes are obtained after 7 and 28 days of curing. This experimental study shows that the concrete made with quarry dust might not be as workable as normal concrete but it gives higher strength than the conventional concrete. ...

(DOC) EFFECT OF QUARRY DUST AS PARTIAL REPLACEMENT OF …

Quarry dust is a waste obtained during quarrying process. It has very recently gained good attention to be used as an effective filler material instead of fine aggregate. Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the partial replacement for natural river sand.

Experimental Study on Partial Replacement of Fine ...

found that the partial replacement of sand with 20%, 30%, 40%, 50% of quarry dust + red soil has given the optimum results. Therefore, this study recommends that if partial replacement of sand with quarry dust +red soil upto 50% in M20 grade of concrete is done, the effective waste management can contribute towards saving of our

Suitability of Quarry Dust as Partial Replacement Material ...

The results of the study also indicates that quarry dust can be utilised as partial replacement material to sand, in the presence of silica fume or fly ash, to produce concretes with fair ranges ...

An Experimental Study On Usage Of Quarry Dust As Partial ...

An Experimental Study On Usage Of Quarry Dust As Partial Replacement For Sand In Concrete And Mortar. 1K. Subramanian, 2A. Kannan . 1Professor And Head Of The Department, Civil Engineering,Coimbatore Institute Of Technology,Coimbatore . 2Research Scholar, Coimbatore Institute Of Technology,Coimbatore .

©Copyright © 2019.Company NIM All rights reserved.sitemap1sitemap2